Dometic TCW1152 User Manual

820 41 72 24USERUSERs MANUs MANUAL - AL - NONOTICE DUTILISTICE DUTILISAATION -TION -MANUMANUAL DEL USUAL DEL USUARIOARIOTCW 1152ICE LINING REFRIGE

10Fill the tube with water leaving a space of about 10 cmUNFILLED at the top (fig. 13). Replace the plug.(Examine for any leakage of water. Leaking tu

115.Lift up and take out the plastic floors of the ILR (fig.15).The floors can be lifted by using the holes of thefloors.6.Fill the ice-packs with cle

128.Make sure that the above actions 5, 6, and 7 hasbeen done for the smaller chamber, too. NOW THEILR IS READY TO STARTCheck the required function of

133.Connect the plug of the power supply cord to the wallsocket and put ON the switch, if any. The `yellow'indicator light on the right hand side

147.The control thermostat for adjustment of the LR to therecommended temperature is located between 2indicator lamps on the front panel. This has set

159.When the temperature inside the ILR is observed tobe steady for several hours within +4° to +8°C onlythen the vaccines to be preserved should betr

1612.When fresh vaccines are stored in the ILR, the cabinettemperature may go up initially but should fall andcome to the required range after few hou

173.Examine the display plate on the lid. If it displays`Refrigerator' function, slide it out from its frame,reverse and put it back to display `

185. TO USE A FREEZERFig. 30.6.Allow the ILR to run. The temperature inside thecabinet will be indicated on the thermometer on thefront side. Observe

199.Water in the tubes will be frozen fully within 1-3 days,depending on different conditions (fig. 31 )10.Put one layer of ice-packs (filled with wat

USER MANUAL2ICE LINING REFRIGERATOR FREEZERHandleRubber gasketIce lining,plastic tubesData labelThermometer85010501465CompressorcompartmentPilot lamp

2012.After storing the vaccines, keep the lid properly closedand locked (fig. 33)`T0 USE ILR PRESENTLY RUNNINGAS `FREEZER' TO WORK AS`REFRIGERATO

21DEFROSTING & CLEANINGPROCEDURE1.Switch OFF the power supply to the ILR and removethe plug of its power supply cord from the wall socket.2.Prepar

225.Open the drainage plug at the bottom, outside thecabinet.Keep a suitable container under the drain hose tocollect the defrost water (fig. 34)6.Kee

237.Clean the ILR carefully as below,a) Wash all parts inside the cabinet with warm waterand mild detergent.b) Clean the lid and the lid seal (gasket)

24DAILY1. Take temperature readings from the thermometersand note down the temperature and the time ofreading.Keep the temperature records systematica

25IMPORTANT:When an ILR is found to be not working at all or notworking properly, see that the vaccine temperature iswithin the recommended limits. Do

264.If the compressor is observed to be runningcontinuously but no cooling is attained - this may bedue to leakage of refrigerant gas from the system

27IF THE ILR IS TO BE SHUT DOWN FORTRANSPORTATION ETC.Disconnect the power-supply plug from socketAllow the ice in the liner tuber (if any) to melt an

1. GENERAL INFORMATION...page 42. INSTALLATION ...

THE ILROne of the most important links in the cold-chain is IceLining Refrigerator (ILR). This is a unit which operateson the principle of vapour comp

Check the manufacturer's plate, at the back of the ILRand make sure that the ILR has correct voltage forlocal supply, i.e. 1 15 or 230 volts (fig

3.EXAMINE the compressor compartment (fig. 3;Check carefully for any damage, dislocation orlooseness etc. of the components, specially atlocations A,

LOCATION B (fig 5)Check that the incoming electrical connections of thepower supply cord to the terminal strip are tight.LOCATION C (fig. 6)Check that

84.Refit side cover of the compressor compartment intoposition refixing the screws holding the side cover (fig.8)6.INSTALL firmly the ILR on a levelfl

98.Connect the leads of the power supply cord to asuitable 3-pin plug as shown below (fig. 10)Lead of cord Pin of plug Green/yellow Earth Blue Neutral